Product ID:V 30026 NEUTRAL GELCOAT
MSDS Date:01/01/1992
FSC:6850
NIIN:00N039350
MSDS Number: BRLBR

FERRO CORP

115 SKYLINE DR
SOUTH PLAINFIELD, NJ 07080
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 908-756-1225

Preparer: K.K.R.

Cage: FERRC

FERRO CORP.

SOUTH PLAINFIELD, NJ 07080 US

Telephone: 908-756-1225

Cage: 7L111

4.5@68F

CAS: 100-42-5

RTECS: WL3675000

Fraction By Weight: 35.72%

OSHA PEL 100 PPM

ACGIH TLV: S,50PPM/100STEL;9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

BY MOUTH TO AN UNCON PERSON.

RTECS: 9999999ZZ

INTO PROD. NEVER MIX PROMOTOR & CATALYST

RTECS: 9999999ZZ

(VAP, LIQ OR SOLID), ALL HAZ PREC LISTED IN MSDS MUST

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAN CAUSE SEV IRRIT
W/BURNING SENSATION.SKIN: MAY CAUSE IRRIT,DERM.SKIN ABSORP OF
STYRENE CAN OCCUR TO SIGNIFICANTLY INCR OVEREXP FROM OTHER ROUTES
OF EXPOS.INHAL: STYRENE OVEREXP CAUSES RE SP TRACT IRRIT.HIGH
LEVELS CAN CAUSE ANESTH EFTS/CNS DEPRESS.MAY BE FATAL @ 10,000 PPM
STYRENE.(EFTS OF OVEREXP)
Explanation of Carcinogenicity:STYRENE: GROUP 2B(IARC),7,345,87.
Effects of Overexposure:HLTH HAZ: MAY CAUSE ALLERGIC RESP RXN, MECH
IRRIT. EXCESS EXPOS TO TALC MAY CAUSE BRONCH. INGEST: HARMFUL/FATAL
IF SWALLOWED! CAUSES GI IRRIT & WILL CONTRIBUTE TO SYSTEMIC EFTS.
CHRONIC: PRLNGD & RPTD SKIN CONT MAY CAUSE DERM &/OR ALLERGICRXN.
PRLNGD OVEREXP CAN CAUSE SYMPS OF NAUS, HDCH, VOMIT, LOSS OF (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:IMMED FLUSH W/LOTS OF WATER FOR @ LST 15 MIN & GET
PROMPT MED ATTN! SKIN: WASH THORO. REMOVE & WASH CONTAMD CLTHG
BEFORE REUSE. SEE MD IF IRRIT IS PRESENT/PERSISTS. INHAL: REMOVE
FROM EXPOS TO WE LL VENTD AREA. MAKE COMFORTABLY WARM BUT NOT HOT.
USE OXYGEN/ARTF RESP AS REQD. SEE MD IF IRRIT PERSISTS. INGEST:
CALL A MD IMMED! ONLY INDUCE VOMIT @ INSTRUCTIONS OF A MD. NEVER
GIVE ANYTHING (ING 2)

Flash Point Method:TCC
Flash Point:85F,29.4C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:HIGHLY FLAMM. CAN POLYMERIZE WHEN HEATED.
SEALED CONTRS CAN RUPTURE EXPLOS WHEN HEATED. COMBUST CAN PRDCE TOX
GASES. TREAT AS OIL FIRE. VAPS ARE (SUPP DATA)

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE AREA
AND MAINTAIN VENTILATION. USE ALL DESCRIBED PROTECTIVE MEASURES AND
EQUIPMENT. USE ABSORBENT MATERIAL, SUCH AS CLAY/SAND, TO COLLECT
AND CONTAIN FOR SALV AGE AND DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN CLSD CONTRS AWAY FROM
SUNLIGHT, HEAT, FLAMES & SPARKS. STORE BELOW 100F, 60-80F
PREFERRED. DO NOT CUT, PUNCTURE/WELD ON OR NEAR CONTR.
Other Precautions:DO NOT STORE NEAR FOOD/FEED. AVOID IMPROPER ADDN OF
PROMOTOR &/OR CATALYST. CONSULT PROD BULLETIN. PROMOTORS (METAL ORG
SUCH AS COBALT OR ANALINE TYPE) & CATALYST (ORG PEROXIDE TYPE) USE
W/PROD, SHOUL D ALWAYS BE PREMIXED SEPARATELY (ING 3)

Respiratory Protection:IN ABSENCE OF PROPER VENTILATION USE NIOSH/MSHA
APPROVED RESPIRATOR.
Ventilation:VENTILATE TO MAINTAIN EXPOS BELOW PUBLISHED EXPOSURE
LIMITS. USE EXPLOSION PROOF MOTORS AND WIRING.
Protective Gloves:IMPERVIOUS(RUBBER, NITRILE) GLOVES.
Eye Protection:CHEM WORK GOG W/FULL LNGTH FSHLD.
Other Protective Equipment:SFTY SHOWERS & EYE WASH STATIONS W/IN 10
SECONDS OF WORK STATION. WHERE SPLASH CAN OCCUR, USE AN APRON.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health
EXPLO YAZ: HVR/AIR, CAN TRAVEL ALONG GROUND/THRU VENT SYS, & BE IGNITED
BY SPARKS, FLAMES/STATIC. WATER MAY BE USED TO KEEP FIRE-EXPOSED
CONTRS COOL UNTIL FIRE IS OUT. EFTS OF OVEREXP: APPETITE & GEN
WEAKNESS. PRLNGD EXPOS TO EXCESS QTY OFTALC CAN RSLT IN SCARRING OF
LUNGS/COVERING OF LUNGS.

Boiling Pt:B.P. Text:295F,146C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.2(H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NONE
Appearance and Odor:LIQUID WITH STYRENE ODOR

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES, AND OTHER OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:OXIDES OF CARBON; INCOMPLETELY BURNED
HYDROCARBONS.
Conditions to Avoid Polymerization:SUNLIGHT, HEAT, FLAMES, SPARKS,
CONTAMINATION, PROLONGED STORAGE ABOVE 100F.

Waste Disposal Methods:PACKAGE IN D.O.T. APPROVED CONTAINERS AND
TRANSPORT TO AN EPA APPROVED TREATMENT, STORAGE, AND DISPOSAL (TSO)
FACILITY. DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS .

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.